Evaluating Combustion, Performance and Emission Characteristics of CI Engine Operating on Diesel Fuel Enriched with HHO Gas

Alfredas Rimkus 1 , Saugirdas Pukalskas 1 , Romualdas Juknelevičius 1 , Jonas Matijošius 1  und Donatas Kriaučiūnas 1
  • 1 Vilnius Gediminas Technical University, 03224, Vilnius, Lithuania

Abstract

Research of efficient and ecological parameters was carried out with compression ignition (CI) engine using diesel fuel and additionally supplied hydrogen and oxygen (HHO) gas mixture. HHO gas is produced by electrolysis when the water was dissociating. At constant engine’s brake torque and with increasing HHO gas volumetric concentration in taken air up to 0.2%, engine efficient indicators varies marginally, however, with bigger HHO concentration these parameters becomes worse. HHO increases smokiness, but it decreases NOx concentration in exhaust gas. Numerical analysis of combustion process using AVL BOOST software lets to conclude that hydrogen, which is found in HHO gas, ignites faster than diesel fuel and air mixture. Hydrogen combustion before TDC makes a negative work and it changes diesel fuel combustion process – diesel ignition delay phase becomes shorter, kinetic (premixed) combustion phase intensity gets smaller.

Falls das inline PDF nicht korrekt dargestellt ist, können Sie das PDF hier herunterladen.

  • [1] Abu-Jrai, A. M., Al-Muhtaseb, A. H., Hasan, A. O., Combustion, performance, and selective catalytic reduction of NOx for a diesel engine operated with combined tri fuel (H2, CH4, and conventional diesel), Energy, 119, pp. 901-910, 2017.

  • [2] Alrazen, H. A., Abu Talib, A. R., Adnan, R., Ahmad, K. A., A review of the Effect of hydrogen addition on the performance and emissions of the compression – ignition engine, Renewable and Sustainable Energy Reviews, 54, pp. 785-796, 2016.

  • [3] Chaisermtawan, P., Jarungthammachote, S., Chuepeng, S., Kiatiwat, T., Gaseous emissions and combustion efficiency analysis of hydrogen-diesel dual fuel engine under fuel-lean condition, Am. J. Applied Sci, 9(11), pp. 1813-1817, 2012.

  • [4] Chen, K., Karim, G. A., Watson, H. C., Experimental and analytical examination of the development of inhomogeneities and auto ignition during rapid compression of hydrogen-oxygen-argon mixtures, Journal of Engineering for Gas Turbines and Power, 125(2), pp. 458-465, 2003.

  • [5] Chintala, V., Subramanian, K. A., Assessment of maximum available work of a hydrogen fueled compression ignition engine using exergy analysis, Energy, 67, pp. 162-175, 2014.

  • [6] Chintala, V., Subramanian, K. A., A comprehensive review on utilization of hydrogen in a compression ignition engine under dual fuel mode, Renewable and Sustainable Energy Reviews, 70, pp. 472-491, 2017.

  • [7] Cipriani, G., Di Dio, V., Genduso, F., La Cascia, D., Liga, R., Miceli, R., Galluzzo, G. R., Perspective on hydrogen energy carrier and its automotive applications, International Journal of Hydrogen Energy, 39, pp. 8482-8494, 2014.

  • [8] Curley, R., Fossil Fuels, Britannica Educational Publishing, 2012.

  • [9] Deb, M., Paul, A., Debroy, D., Sastry, G. R. K., Panua, R. S., Bose, P. K., An experimental investigation of performance-emission trade off characteristics of a CI engine using hydrogen as dual fuel, Energy, 85, pp. 569-585, 2015.

  • [10] Giakoumis, E. G., Rakopoulos, C. D., Dimaratos, A. M., Rakopoulos, D. C., Exhaust emissions of diesel engines operating under transient conditions with biodiesel fuel blends, Progress in Energy and Combustion Science, 38(5), pp. 691-715, 2012.

  • [11] Gupta, R. B., Hydrogen fuel: production, transport, and storage, Taylor & Francis Group: CRC Press, 2009.

  • [12] Heffel, J. W., NOx emission and performance data for a hydrogen fueled internal combustion engine at 1500 rpm using exhaust gas recirculation, International Journal of Hydrogen Energy, 28, pp. 901-908, 2003.

  • [13] Heywood, J. B., Internal combustion engine fundamentals, McGraw-Hill, 1988.

  • [14] Hordeski, M. F., Alternative fuels—the future of hydrogen, Taylor & Francis Group: The Fairmont Press, 2008.

  • [15] Yilmaz, A. C., Uludamar, E., Aydin, K., Effect of hydroxy (HHO) gas addition on performance and exhaust emissions in compression ignition engines, International Journal of Hydrogen Energy, 35, pp. 11366-11372, 2010.

  • [16] Jarungthammachote, S., Chuepeng, S., Chaisermtawan, P., Effect of hydrogen addition on diesel engine operation and NOx emission: A thermodynamic study, Am. J. Applied Sci, 9, pp. 1472-1478, 2012.

  • [17] Lewis, B., von Elbe, G., Combustion, Flames and Explosions of Gases, (3rd Edition), Academic Press, New York 1987.

  • [18] Li, J., Huang, H., Kobayashi, N., Wang, C., Yuan, H., Numerical study on laminar burning velocity and ignition delay time of ammonia flame with hydrogen addition, Energy, 126, pp. 796-809, 2017.

  • [19] Masjuki, H. H., Ruhul, A. M., Mustafi, N. N., Kalam, M. A., Arbab, M. I., Fattah, I. M. R., Study of production optimization and effect of hydroxyl gas on a CI engine performance and emission fueled with biodiesel blends, International Journal of Hydrogen Energy, 41, pp. 14519-14528, 2016.

  • [20] Mollenhauer, K., Tschoeke, H., Handbook of diesel engines, Springer, 2010.

  • [21] Momirlan, M., Veziroglu, T. N., The properties of hydrogen as fuel tomorrow in sustainable energy system for a clean planet, International Journal of Hydrogen Energy, 30, pp. 795-802, 2005.

  • [22] Ozcanli, M., Akar, M. A., Calik, A., Serin, H., Using HHO (Hydroxy) and hydrogen enriched castor oil biodiesel in compression ignition engine, International Journal of Hydrogen Energy, 42 (36), pp. 23366-23372, 2017.

  • [23] Rakopoulos, C. D., Giakoumis, E. G., Diesel engine transient operation, Springer, 2009.

  • [24] Rakopoulos, D. C., Rakopoulos, C. D., Giakoumis, E. G., Papagiannakis, R. G., Kyritsis, D. C., Influence of properties of various common bio-fuels on the combustion and emission characteristics of high-speed DI (direct injection) diesel engine: Vegetable oil, bio-diesel, ethanol, n-butanol, diethyl ether, Energy, 73, pp. 354-366, 2014.

  • [25] Ramadhas, A. S., Alternative fuels for transportation, Taylor & Francis Group: CRC Press, 2011.

  • [26] Rimkus, A., Pukalskas, S., Matijošius, J., Sokolovskij, E., Betterment of ecological parameters of a diesel engine using brown’s gas, Journal of Environmental Engineering and Landscape Management, 21(2), pp. 133-140, 2013.

  • [27] Roy, M. M., Tomita, E., Kawahara, N., Harada, Y., Sakane, A., An experimental investigation on engine performance and emissions of a supercharged H2–diesel dual-fuel engine, International Journal of Hydrogen Energy, 35, pp. 844-853, 2010.

  • [28] Santilli, R. M., A new gaseous and combustible form of water, International Journal of Hydrogen Energy, 31, pp. 1113-1128, 2006.

  • [29] Saravanan, N., Nagarajan, G., An experimental investigation of hydrogen-enriched air induction in a diesel engine system, International Journal of Hydrogen Energy, 33, pp. 1769-75, 2008.

  • [30] Saravanan, N., Nagarajan, G., Narayanasamy, S., An experimental investigation on DI diesel engine with hydrogen fuel, Renewable Energy, 33, pp. 415-421, 2008.

  • [31] Srinivasan, S., Salzano, F. J., Prospects for hydrogen production by water electrolysis to be competitive with conventional methods, International Journal of Hydrogen Energy, 2, pp. 53-59, 1977.

  • [32] Stiesch, G., Modeling Engine spray and combust ion processes, Springer-Verlag Berlin Heidelberg, 2010.

  • [33] Surygala, J., Hydrogen as a fuel, Warszawa: Wydawnictwa Naukowo-Techniczne, 2008.

  • [34] Szwaja, S., Grab-Rogalinski, K., Hydrogen combustion in a compression ignition diesel engine, International Journal of Hydrogen Energy, 34 (10), pp. 4413-4421, 2009.

  • [35] Talibi, M., Hellier, P., Ladommatos, N., Combustion and exhaust emission characteristics, and in-cylinder gas composition, of hydrogen enriched biogas mixtures in a diesel engine, Energy, 124, pp. 397-412, 2017.

  • [36] Uludamar, E., Yıldızhan, S., Aydin, K., Ozcanli, M., Vibration, noise and exhaust emissions analyses of an unmodified compression ignition engine fuelled with low sulphur diesel and biodiesel blends with hydrogen addition, International Journal of Hydrogen Energy, 41, pp. 1-10, 2016.

  • [37] Vibe, I. I., Brennverlauf und Kreisprozeß von Verbrennungsmotoren, Berlin: Verlag Technik, 1970.

  • [38] Wang, H. K., Cheng, C. Y., Chen, K. S., Lin, Y. C., Chen, C. B., Effect of regulated harmful matters from a heavy-duty diesel engine by H2/O2 addition to the combustion chamber, Fuel, 93, pp. 524-527, 2012.

  • [39] Whiete, C. M., Steeper, R. R., Lutz, A. E., The hydrogen-fueled internal combustion engine: a technical review, International Journal of Hydrogen Energy, 31, pp. 1292-1305, 2006.

  • [40] Zoulias, E. I., Lymberopoulos, N., Hydrogen-based autonomous power systems, Springer, 2008.

OPEN ACCESS

Zeitschrift + Hefte

Suche