Carbonaceous Soot from Thermal Decomposition of Kerosene: A Pioneering Report for Paint Preservation

Open access

Abstract

Bacterial resistance to conventional paint biocides is widely documented. However, an investigation regarding the preservative potential of carbonaceous soot as a viable alternative is novel. Fresh paint samples (SA, SB and SC) were collected in duplicates from a reputable paint manufacturing company in Lagos, Nigeria. SA was produced with conventional paint biocide, SB and SC were without biocide. All samples were inoculated with 0.032 × 106 cfu/mL of Pseudomonas aeruginosa PA01 (NC 002516.2) previously isolated from spoilt paints and identified by the 16S rDNA analysis. SB was supplemented with crude soot (10 g/L of distilled water) at 200 mL v/v. The preservative efficiency of soot was investigated by monitoring the bacterial population (BP), optical density (OD600nm), viscosity (VIS), the transmittance (TR) and specific gravity (SG) of the samples bi-weekly for 14 weeks. BP increased drastically from 0.032-31.61 × 106 and from 0.032-112.93 × 106 in SA and SC respectively. In contrast, SB increased from 0.032-24.63 × 106 by week 4 but reduced from 24.63 – 10.95 × 106 by week 14. The OD of SA increased from 1.55 to 1.98 by week 8 and decreased to 1.74 by week 14. SB had a decrease from 1.60 to 1.49 by week 4 and increased to 1.63 by week 14, while SC increased from 1.59 to 2.54 by the 14th week.TR increased from 1.80 to 2.30 and 1.25 to 2.20 in SA and SC respectively. In contrast, TR decreased from 2.00 to 1.25 in SB. The viscosity and specific gravity values of all the samples decreased with time with the highest decrease observed in SC and the lowest in SB. The test crude soot showed preservative potential in paints.

If the inline PDF is not rendering correctly, you can download the PDF file here.

  • Adeleye I. Adeleye O. 1999 Isolation and identification of microbes associated with paints and weathered painted walls. J. Sci. Res. Dev 4 71-76.

  • Alba J. Conde E. Pérez-Guevara F. 2003 Degradation of the main components of cellulose-paint thinner by the mould Scopulariopsis brevicaulis cultured on rice hulls. Letters in applied microbiology 37 7-11.

  • Albanis T. Lambropoulou D. Sakkas V. Konstantinou I. 2002 Antifouling paint booster biocide contamination in Greek marine sediments. Chemosphere 48 475-485.

  • Bastos F.S. Castro P.M. Ferreira Jorge R. 2003 Biological treatment of a contaminated gaseous emission from a paint and varnish plant—from laboratory studies to pilot-scale operation. Journal of Chemical Technology and Biotechnology 78 1201-1207.

  • Briggs M. 1980 Emulsion Paint Preservation Factory practice and Hygiene. Paint Research Association Technical Report.

  • Chau Y. Maguire R. Brown M. Yang F. Batchelor S. 1997 Occurrence of organotin compounds in the Canadian aquatic environment five years after the regulation of antifouling uses of tributyltin. Water quality research journal of Canada 32 453-521.

  • Cho J.D. Ju H.T. Hong J.W. 2005 Photocuring kinetics of UV-initiated free-radical photopolymerizations with and without silica nanoparticles. Journal of Polymer Science Part A: Polymer Chemistry 43 658-670.

  • Chung H. Ku M.-S. Lee J.-S. 1999 Comparison of near-infrared and mid-infrared spectroscopy for the determination of distillation property of kerosene. Vibrational spectroscopy 20 155-163.

  • Contant S. Caritá Júnior G. Machado P. Lona L. 2010 Evaluation of the effect of dry-film biocides on paint film preservation using neural networks. Brazilian Journal of Chemical Engineering 27 643-651.

  • Da Silva V. 2003 Microbial deterioration of paints. Microbiologist 4 43.

  • Del Amo B. Romagnoli R. Deyá C. González J. 2002 High performance water-based paints with non-toxic anticorrosive pigments. Progress in Organic Coatings 45 389-397.

  • Dey B. Hashim M. Hasan S. Gupta B.S. 2004 Microfiltration of water-based paint effluents. Advances in Environmental Research 8 455-466.

  • Dikio E.D. 2011 Morphological characterization of soot from the atmospheric combustion of kerosene. Journal of Chemistry 8 1068-1073.

  • Edge M. Allen N. Turner D. Robinson J. Seal K. 2001 The enhanced performance of biocidal additives in paints and coatings. Progress in Organic Coatings 43 10-17.

  • El-Sayed A.H.M. Mahmoud W.M. Davis E.M. Coughlin R.W. 1996 Biodegradation of polyurethane coatings by hydrocarbon-degrading bacteria. International biodeterioration & biodegradation 37 69-79.

  • Gillatt J. 1992 Bacterial and fungal spoilage of waterborne formulations. Surface coatings international 75 387-392.

  • Guglielminetti M. Morghen C.D.G. Radaelli A. Bistoni F. Carruba G. Spera G. Caretta G. 1994 Mycological and ultrastructural studies to evaluate biodeterioration of mural paintings. Detection of fungi and mites in frescos of the monastery of St damian in assisi. International biodeterioration & biodegradation 33 269-283.

  • Kwon H.-S. Yang E.-H. Lee S.-H. Yeon S.-W. Kang B.-H. Kim T.-Y. 2005 Rapid identification of potentially probiotic Bifidobacterium species by multiplex PCR using species-specific primers based on the region extending from 16S rRNA through 23S rRNA. FEMS microbiology letters 250 55-62.

  • Martinez K. Ferrer I. Hernando M. Fernández-Alba A.R.g. Marcé R.M. Borrull F. Barcelo D. 2001 Occurrence of antifouling biocides in the Spanish Mediterranean marine environment. Environmental technology 22 543-552.

  • McPherson M. Moller S. Graham A. 2000. PCR; The Basics Bios (Scientific Publishers Ltd).

  • Ohwoavworhua F. Adelakun T. 2005 Phosphoric acid-mediated depolymerization and decrystallization of α-Cellulose obtained from corn cob: preparation of low crystallinity cellulose and some physicochemical properties. Tropical Journal of Pharmaceutical Research 4 509-516.

  • Rammohan R. Yassen M. 2003 Determination of intrinsic viscosity by single specific viscosity measurements. J. Appl. Poly. Sci 31 2501-2508.

  • Reilly J.A. 1991 Celluloid objects: their chemistry and preservation. Journal of the American Institute for Conservation 30 145-162.

  • Thompson J. 1994 Improving the sensitivity of progressive multiple sequence alignment through sequence weighting position-specific gap penalties and weight matrix choice. Nucleic Acids Res 22 4673-4680.

  • Varghese S. Kuriakose S. Jose S. 2013 Antimicrobial activity of carbon nanoparticles isolated from natural sources against pathogenic Gram-negative and Gram-positive bacteria. Journal of Nanoscience 2013.

  • Vore R. Pierce J. 1995 8 Preservation of paint formulations In: Preservation of Surfactant Formulations. Springer Netherlands pp. 185-211.

  • Voulvoulis N. Scrimshaw M.D. Lester J.N. 2000 Occurrence of four biocides utilized in antifouling paints as alternatives to organotin compounds in waters and sediments of a commercial estuary in the UK. Marine Pollution Bulletin 40 938-946.

Search
Journal information
Metrics
All Time Past Year Past 30 Days
Abstract Views 0 0 0
Full Text Views 235 134 5
PDF Downloads 131 78 1