Application of catalysts in the treatment of selected waste chloroorganic compounds

Open access

Application of catalysts in the treatment of selected waste chloroorganic compounds

Tetrachloromethane (TCM) and 1,1,2,2-tetrachloroethane (TChE) were oxidized in the temperature range from 300 to 600°C and at contact time of 0.36 s. The following catalysts were applied during the process: the granular one - platinum (0.12%) at the TiO2-SiO2 carrier, platinum ZChO-80 (0.15%) at γ-Al2O3 carrier, palladium (1%) at γ-Al2O3 carrier and monolithic platinum-rhodium catalyst (Pt - 0.09% and Rh - 0.04%) at the cordierite carrier.

The substrates were oxidized in the presence of the above mentioned catalysts with various efficiencies depending on the molecular structure and the type of the catalyst. Palladium contact appeared to be the most active among the others. In the presence of this catalyst, total oxidation of TCM and TChE proceeded at the temperature of 425 and 500°C, respectively. The content of PCDD/Fs in gaseous products obtained during the oxidation of both substrates, was significantly lower than the admissible value of the toxicity equivalent (0.1 ng TEQ/m3).

Przondo J., Rogala J.: Przemysłowa instalacja spalania ciekłych odpadów chloroorganicznych w Z. Ch. "Rokita" S. A., Przem. Chem., 1996, 75, 98.

Lewandowski G., Milchert E., Doroczyński A.: Spalanie odpadowych chloropochodnych organicznych odzyskiem chlorowodoru, Przem. Chem., 2005, 84, 516.

Agarval S. K., Spivey J. J., Butt J. B.: Catalyst deactivation during deep oxidation of chlorocarbons, Appl. Catal. A: General, 1992, 82, 259.

Cybulski A., Moulijn J. A.: Monoliths in heterogenous catalysis, Catal. Rev.-Sci. Eng., 1994, 36, 179.

Lester G. R.: Catalytic destruction of hazardous halogenated organic chemicals, Catal. Today, 1999, 53, 407.

Corella J., Toledo J., Padilla A. M.: On the selection of the catalysts among the commercial platinum-based ones for total oxidation of some chlorinated hydrocarbons, Appl. Catal. B. Environ., 2000, 27, 243.

Kaźmierczak M., Gorzka Z., Paryjczak T., Żarczyński A.: Treatment of toxic organic compounds occurring in industrial wastes with application of catalysts, Pol. J. Chem. Technol., 2002, 4, 8.

Kułażyński M., Van Ommen J. G., Trawczyński J., Walendziewski J.: Catalytic combustion of trichloroethylene over TiO2-SiO2 supported catalysts, Appl. Catal. B: Environmental, 2002, 36, 239.

Żarczyński A., Gorzka Z., Paryjczak T., Kaźmierczak M., Szczepaniak B.: Dioxins in the process of 1,1,2,2-tetrachloroethane oxidation with the application of monolithic catalysts, Pol. J. Chem. Tech., 2005, 7(2), 100.

Żarczyński A., Kaźmierczak M., Gorzka Z., Zaborowski M.: Dioksyny w procesie utleniania 1,1,2,2-tetrachloroetanu w obecności wybranych katalizatorów. Chem. Inż. Ekol.2005, 12(S1), 113.

Koyer-Gołkowska A., Musialik-Piotrowska A., Rutkowski J.: Oxidation of chlorinated hydrocarbons over Pt-Rh-based catalyst. Part 1. Chlorinated methanes, Catal. Today, 2004, 90, 133.

Finocchio E., Busca G., Notaro M.: A review of catalytic processes for the destruction of PCDD and PCDF from waste gases, Appl. Catal. B: Environmental, 2006, 62, 12.

Żarczyński A., Gorzka Z., Paryjczak T., Zaborowski M., Kaźmierczak M.: Utylizacja tetrachloropochodnych z udziałem katalizatorów monolitycznych. Przem. Chem.2006, 85 (8 - 9), 1095.

Kaźmierczak M., Gorzka Z., Żarczyński A., Paryjczak T., Zaborowski M.: Activity of granular and monolithic catalysts during oxidation of selected organic chlorine compounds, Environmental Engineering, pp. 365 - 369, Taylor & Francis Group, Londyn 2007.

European Standard EN-1948, ICS 13.040.40 Stationary source emissions. Determination of the mass concentration of PCDD/Fs. Part 1. Sampling, Part 2. Extraction and clean-up, Part 3. Identification and Quantification.

Rozporządzenie Ministra Środowiska z dn. 20. 12. 2005 r. w sprawie standardów emisyjnych z instalacji. Dz. U. 2005, nr 260, poz. 2181.

Makles Z., Świątkowski A., Grybowska S.: Niebezpieczne dioksyny, Arkady, Warszawa, 2001.

Polish Journal of Chemical Technology

The Journal of West Pomeranian University of Technology, Szczecin

Journal Information


IMPACT FACTOR 2017: 0.55
5-year IMPACT FACTOR: 0.655

CiteScore 2017: 0.65

SCImago Journal Rank (SJR) 2017: 0.202
Source Normalized Impact per Paper (SNIP) 2017: 0.395

Metrics

All Time Past Year Past 30 Days
Abstract Views 0 0 0
Full Text Views 219 216 10
PDF Downloads 44 44 2